Oilfree centrifugal electric compressor with foil gasdynamic bearings


Cite item

Full Text

Open Access Open Access
Restricted Access Access granted
Restricted Access Subscription or Fee Access

Abstract

The article gives the description of a highspeed oilfree electric compressor with foil gasdynamic bearings and a synchronous permanent magnet electric drive. During experiments, the refrigeration system has been optimized, and the total power of losses in the bearings and losses on the ventilation of the rotor has been measured. The tests were carried out in the vacuum regime at the inlet up to -0,5 bar; also the tests were performed in the generator regime. This compressor may be used as an independent electric one for air, gases, including refrigerants, and also as a compressor unit in the capacity of a part of a refrigeration or cryogenic plant. In generator mode, the compressor is applicable in waste heat recovery systems operating on the Organic Rankine Cycle (ORC).

Full Text

Restricted Access

About the authors

A. V Polikarpov

NII of mechanics of MSU

Email: polikarpovav@imec.msu.ru
Moscow, Russia

A. P Vikulov

NII of mechanics of MSU

Email: wap@imec.msu.ru
Moscow, Russia

S. N Zotov

NII of mechanics of MSU

Email: zotoff@inbox.ru
Moscow, Russia

A. A Kostenko

NII of mechanics of MSU

Email: kosrk1@gmail.com
Moscow, Russia

I. I Galperin

«Company «NOEMI» Ltd

Email: galperin@noemi.ru
Moscow, Russia

A. D Labutin

«Company «NOEMI» Ltd

Email: labutin@noemi.ru
Moscow, Russia

References

  1. Леонов В.П., Максимович Т.И. Лепестковые газовые подшипники турбомашин: методические указания. - М.: Издво МГТУ им. Н.Э. Баумана, 2002.
  2. Поликарпов А.В., Костенко А.А., Розеноер Т.М., Валеев А.Г., Щучкин В.В., Малинин В.В. Применение опыта проектирования криогенных турбодетандеров при разработке турбоэлектрогенератора мощностью 1 кВт для установки с органическим циклом Ренкина // Холодильная техника. 2017. № 11. С. 42-47.
  3. Щедухин С.И., Поликарпов А.В., Викулов А.П., Зотов С.Н., Розеноер Т.М., Костенко А.А., Воронов В.А. Безмасляный турбодетандер природного газа на лепестковых газодинамических подшипниках // Холодильная техника. 2017. № 6. С. 46-50.

Copyright (c) 2020 Polikarpov A.V., Vikulov A.P., Zotov S.N., Kostenko A.A., Galperin I.I., Labutin A.D.

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

This website uses cookies

You consent to our cookies if you continue to use our website.

About Cookies