Tractors and Agricultural MachineryTractors and Agricultural Machinery0321-44432782-425XEco-Vector6665710.31992/0321-4443-2019-6-58-64Research ArticleEfficiency of cleaning and the life cycle of the modernized filter for rough cleaning of diesel fuelHalturinD. VPhD in Engineeringdmitriihalturin@mail.ruLysunecA. VPhD in Engineeringdmitriihalturin@mail.ruTomsk State University of Architecture and Building15122019866586428042021Copyright © 2019, Halturin D.V., Lysunec A.V.2019The paper considers the problem of the reliability of the fuel equipment of tractor diesel engines at low temperatures. The main problem of the operation of such engines is the deterioration of fuel pumpability through the fuel lines, waxing and clogging of fine filters. The authors propose a new design of the coarse filter (CF), where the filter element is a filter tape made of nonwoven needle-punched material with variable compression, which has increased filtration efficiency with the possibility of simultaneous heating of the fuel. The advantage of the proposed changes is the use of a standard coarse filter housing. Performance tests are presented. According to the results of operational tests of the upgraded coarse filter, it was found that, unlike the standard element, the mass concentration of contaminants is reduced by about half, and the probability of dropping out particles larger than 30 microns is 90 %. The particle size distribution curves of contaminants after a standard and upgraded filter and a resource characteristic are built. The results of comparative operational tests of filters for pollution are presented. The pressure drop across the filter at the onset of maintenance is estimated, and an increase in scheduled filter replacement is suggested. The degree of compression of the filtering material was determined to exclude the appearance of particles larger than 35 μm after the CF.diesel fuelcleaning efficiencyfiltrationheatingincreased life cycleдизельное топливоэффективность очисткифильтрацияподогревповышение ресурса[Зыков С.В. Повышение чистоты топлива в системах топливоподачи дизельных двигателей сельскохозяйственных машин: дис. ... канд. техн. наук. М.: МГАУ, 2003. 186 с.][Лысунец А.В. Совершенствование топливных систем и средств их технического обслуживания с целью повышения надежности дорожных и строительных машин: дис. … канд. техн. наук. Томск, 2006. 137 с.][Халтурин Д.В. Подогрев и очистка топлива в условиях низких температур с целью повышения работоспособности сельскохозяйственных дизельных тракторов: дис. … канд. тен. наук. Новосибирск, 2015. 161 с.][Удлер Э.И. Фильтрация нефтепродуктов. Томск: Изд-во Томск. ун-та, 1988. 215 с.][Сырбаков А.П. Обеспечение работоспособности топливоподающей системы дизельных тракторов в условиях отрицательных температур: дис. … канд. техн. наук. Новосибирск, 2004. 167 с.][Гринберг Л.С. Запуск дизеля при низких температурах // Механизация и электрификация сельского хозяйства. 1990. № 2. С. 6.][Киселев Г.М. Использование тракторов в зимний период // Механизация и электрификация сельского хозяйства. 1991. № 2. С. 30-31.][Удлер Э.И., Халтурин Д.В. Предварительная очистка топлива с подогревом в топливных системах машин // Тракторы и сельхозмашины. 2013. № 7. С. 47-49.][Удлер Э.И., Халтурин Д.В., Спирин Е.Н. Модернизация топливной системы дизеля сельскохозяйственного трактора // Тракторы и сельхозмашины. 2016. № 11. С. 19-22.][Удлер Э.И., Халтурин Д.В., Готовцева Т.А., Пивнев Д.Е. Фильтроэлемент: патент на изобретение RUS 2186608, Российская Федерация; опубл. 10.08.02, Бюл. № 31.][Удлер Э.И., Зуев В.И. Фильтрующие топливно-масляные элементы из бумаги и картона. Томск: Изд-во Томск. ун-та, 1983. 140 с.][Удлер Э.И. Фильтрация углеводородных топлив. Томск: Изд-во Томск. ун-та, 1981. 152 с.]