Izvestiya MGTU MAMIIzvestiya MGTU MAMI2074-05302949-1428Moscow Polytechnic University6686810.17816/2074-0530-66868Research ArticleEfficiency of application of direct-drive circuit for improvement of starting characteristics of gas turbine engineChechulinA. YuPh.D.ntt2008@yandex.ruKrivoshevI. ADr.Eng.krivosh777@mail.ruUfa State Aviation Technical University15122017114708030042021Copyright © 2017, Chechulin A.Y., Krivoshev I.A.2017The effectiveness of measures to improve the starting characteristics of gas turbine engines (GTE) is considered. To improve the reliability of the GTE launch, it is proposed to use the so-called gearless GTE scheme, created for a “more electric aircraft”, which uses an integrated high-speed starter generator and electric drive units for fuel, oil and other life support of gas turbine engines. With the help of a nonlinear dynamic mathematical startup model, the effect of the magnitude of the given moment of inertia of the rotor on the starting characteristics of the gas turbine engine is evaluated. Change it in the direction of reduction was carried out by replacing the gearbox with attachments to one unit a high-speed starter-generator, installed coaxially with the rotor. Determination of the value of the given moment of inertia of the rotor, aggregates, bearings was carried out using the developed 3-DCAD-models. In the mathematical model of start-up, the thermal state of the oil system, the mechanical power losses for rotating aggregates, bearings, gears are taken into account. The quantitative dependence of the starting characteristics on the moment of inertia of the GTE rotor and other factors is established. For comparison of the basic APU and APU of the direct-drive circuit simulation of the start in the most stressful operating conditions P H = 101,3 kPa at low negative temperatures t H = -40 °C and under normal conditions P H = 101,3 kPa and t H = +15 °C, for “cold” and “hot” state of the engine before starting was made. The tendencies of the moment of inertia of the rotors of the executed and newly created GTE are analyzed. It is shown that the gearless APU in comparison with the basic APU due to the reduction of the moment of inertia by 9,68 % and the reduction of the oil pumped volume in the oil system has a significant improvement in the launch characteristics under ground launch conditions ( P H = 101,3 kPa).direct-drive gas turbine enginereduced moment of inertia of the rotordynamic and 3D CAD-modelssimulation of engine startбезредукторный газотурбинный двигательприведенный момент инерции роторадинамическая и 3D CAD-моделимоделирование запуска[Гуревич О.С., Белкин Ю.С., Гулиенко А.И. Газотурбинный двигатель для «электрического» самолета: направление электрификации газотурбинного двигателей // Труды ЦИАМ № 1346. 2010. С. 21-29.][Кривошеев И.А., Чечулин А.Ю., Шабельник Ю.А. О создании принципиально новых силовых и вспомогательных установок для «полностью электрического самолета» // Научные труды «Инноватика и экспертиза». 2013. Вып. 1(10). С. 64-67.][Чечулин А.Ю. Конкурсное резюме безредукторной ВСУ-120. Конкурс союза Авиапроизводителей России «Авиастроитель года по итогам 2013 года» в номинации: "За успехи в создании систем и агрегатов для авиастроения". М., 2014.][Поляков А.М. и др. Авиационные вспомогательные силовые установки. М.: Машиностроение, 1992. 672 с.][Чурюмов В. Ю. Механика. Ухта : УГТУ, 2013. 155 с.][Бейзельман Р.Д., Цыпкин Б.В., Перель Л.Я. Подшипники качения. Справочник. М. Машиностроение, 1975. 572 с.][Кривошеев И.А., Чечулин А.Ю. Методика учета мощности, затрачиваемой на вращение ротора, в нелинейной динамической модели запуска авиационного ГТД // Вестник ПНИПУ. Аэрокосмическая техника. 2017. № 2. С. 190-202.][Чечулин А.Ю. Опыт доводки пусковых характеристик камеры сгорания ВСУ // Вестник Самарского государственного аэрокосмического университета. 2015. Т. 14. № 2. С. 202-210.][Чечулин А. Ю. Совершенствование методики контроля пусковых характеристик серийных вспомогательных ГТД с применением статистического анализа // Вестник УГАТУ. 2015. Т. 19. № 1. С. 22-28.]